SECTION: 2.20.015 FM2850 1115 Supersedes 1015
Your Peace of Mind is Our Top Priority ® ®
Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.
TECHNICAL DATA SHEET
AQUA-MATE SERIES
Model 212 Sewage/Effluent or Dewatering Pump Builder Series
MATER IALS
PUMP
MOTOR
PRODUCT SPECIFICATIONS Horse Power
1/2
Voltage
115
Phase
1 Ph
Hertz
60 Hz
RPM
3400
Type
Permanent split capacitor
Insulation
Class B
Amps
6.6
Operation
Automatic
Auto On/Off Points
11 1/2” (29 cm) / 5 1/4” (13 cm)
Discharge Size
2" NPT
Solids Handling
2" (50 mm) spherical solids
Cord Length
10' (3 m) standard
Cord Type
UL listed 3-prong plug
Max. Head
19.5' (5.9 m)
Max. Flow Rate
82 GPM (310 LPM)
Max. Operating Temp.
104° F (40° C)
Cooling
Oil filled
Motor Protection
Auto reset thermal overload (1 Ph)
Motor Housing
Cast iron
Pump Housing
Engineered plastic
Base
Engineered plastic
Upper Bearing
Ball bearing
Lower Bearing
Ball bearing
Mechanical Seals
Carbon and ceramic
Impeller Type
Non-clogging vortex
Impeller
Engineered plastic
Hardware
Stainless steel
Motor Shaft
SUS420J2 stainless steel
Gasket
NBR
3 3/8 (86 mm)
6 15/32" (164 mm) 4 23/32" (120 mm)
3 7/16" (87.6 mm)
4 1/4" (108 mm)
2" NPT
15 7/8" (403 mm)
NOTE: The sizing of effluent systems normally requires variable level float(s) controls and properly sized basins to achieve required pumping cycles or dosing timers with nonautomatic pumps. NOTE: See model comparison chart for specific details.
R
Tested to UL778 and CSA22.2 108 Standard
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
5 3/4" (146 mm)
SK3054
15 4.6 Shut-off Head:
METERS
PUMP PERFORMANCE CURVE MODEL 212
FEET
TOTAL DYNAMIC HEAD/FLOW PERDYNAMIC MINUTEHEAD TOTAL SEWAGE AND FLOW PERDEWATERING MINUTE
25
212
Feet Meters 5 1.5 10 3.0 15 4.6 Shut-off Head:
Liters Gal. 82 310 53 201 32 121 19.5 ft. (5.9m)
20
6
TOTAL DYNAMIC HEAD
MODEL
15
4
10 2
5
NOTE: recommended for 2" pipe only
0
PUMP PERFORMANCE CURVE MODEL 212
32 121 19.5 ft. (5.9m)
10
20
30
40
50
60
70
90
80
GALLONS LITERS 0
40
80
120
160 200 240 FLOW PER MINUTE
280
320 153444
MODEL COMPARISON
Model M212
Seal
Mode
Volts
Ph
Single
Auto
115
1
Amps 6.6
HP
Hz
Lbs.
Kg
1/2
60
16.8
7.6
SELECTION GUIDE 1. Integral float-operated mechanical switch, no external control required. 2. See FM1663 for a residential alternator system.
10 40
20
CAUTION
80
40
30
50
60
70
90
80
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
120
160 200 240 FLOW PER MINUTE
280
320
© Copyright 2015 Zoeller® Co. All rights reserved. 502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com